Ford Archives - Page 4 of 7 - The Diesel Doctor

2008 Ford Pickup
Mileage
194,710
Service Date
4/6/2023
Services Performed
DIAG: LIMP MODE, OIL LEAK, RELOCATE BACK PRESSURE SENSOR, EXHAUST FALLING OFF- BU
SHORT BLOCK – REMOVE, RESEAL, AND REINSTALL (INSTALLED WITH LISTED PARTS)
CARRIER BEARING – REMOVE AND REPLACE
FUEL FILTER – REMOVE AND REPLACE (BOTH)
ENGINE OIL – DRAIN, FILL, AND REMOVE AND REPLACE FILTER
TEF K. gave our service a 5 star review on 4/11/2023
2014 Ford F-350 Super Duty
Mileage
167,047
Service Date
3/7/2023
Services Performed
FOUND: TURBO SQUEALING, APPEARS TO BE LEAKING EXHAUST FROM DRIVERS SIDE MANIFOLD. (RECOMMEND REPLACING EXHAUST MANIFOLD, INSPECT TURBO SHAFT PLAY) H.G. 2/15/23 AFTER BUMPER TO BUMPER FOUND: (RECOMMEND TRANSMISSION SERVICE, RECOMMEND COOLANT FLUSH TO PROPER TYPE OF COOLANT, CLEAN AIR FILTER, TRANSFER CASE SERVICE, DIFFERENTIAL SERVICE) H.G. 2/15/23 1PM REMOVED INTAKE AND PLENUM TO ACCESS TURBO INLET, TURBO IMPELLER SHAFT HAS EXCESSIVE PLAY ( RECOMMEND REPLACING TURBO) 2/16/23 H.G. 3PM AFTER REPAIRS NO LEAKS FROM EXHAUST TRUCK RUNS AND DRIVES GOOD AT THIS TIME. 3/6/23 J.U. 3PM
PULL PLENUM TO INSPECT TURBO FOR SHAFT PLAY
TURBOCHARGER – REMOVE AND REPLACE
EXHAUST MANIFOLD – REMOVE AND REPLACE (BOTH)
ENGINE OIL – DRAIN, FILL, REMOVE AND REPALCE FILTER
AIR FILTER – REMOVE, CLEAN, AND REINSTALL
DIFFERENTIAL FLUID – DRAIN AND FILL (REAR)
TRANSFER CASE – DRAIN AND FILL
TRANSMISSION FILTER – REMOVE AND REPLACE (INTERNAL)
ROBERT B. gave our service a 5 star review on 3/7/2023
2017 Ford F-350 Super Duty
Mileage
119,315
Service Date
1/12/2023
Services Performed
FOUND: DURING BUMPER TO BUMPER, TRANSMISSION FLUID DIRTY (RECOMMENDS SERVICE) DIFF AND T-CASE ARE GOOD. REAR APPEARS TO HAVE BEEN DONE. STEERING, SUSPENSION AND BRAKES GOOD. NO SCAN FOR CODES AT THIS TIME NOTHING O/D INDICATOR. CUSTOMER DECLINED SERVICE FOR TRANSMISSION SERVICE TIL LATER. ME/TM 1/12/23 10A
FUEL FILTER – REMOVE AND REPLACE (BOTH)
JASON B. gave our service a 5 star review on 1/12/2023
2011 Ford Expedition EL
Mileage
178,886
Service Date
12/20/2022
Services Performed
FOUND: AIR FILTER DIRTY ( RECOMMEND AIR FILTER) ENGINE OIL LOW, NOT READING ON DIPSTICK. (RECOMMEND OIL CHANGE) COOLANT LEVEL LOW 1/2 GALLON, FOUND STOP LEAK RESIDUE INSIDE OF RADIATOR CAP. (RECOMMEND COOLANT FLUSH AND WATCH FOR LEAKS) POWER STEERING FLUID LOW. (RECOMMEND FILLING) INSIDE ENGINE OIL FILL CAP HAS SLUDGY MILKY RESIDUE, POSSIBLE BLOWN HEAD GASKET. PERFORMED PRESSURE TEST ON COOLING SYSTEM, DOES NOT HOLD PRESSURE, CHECKED FOR EXTERNAL LEAKS, DID NOT FIND ANY (POSSIBLE INTERNAL HEAD GASKET LEAK) BATTERY TESTED GOOD. FRONT AND REAR BRAKE LIFE IS GOOD OVER 50%. H.G. 12/20/22 12PM
AMANDA M. gave our service a 5 star review on 12/20/2022
2013 Ford F-350 Super Duty
Mileage
157,456
Service Date
10/20/2022
Services Performed
FOUND: P0625 GENERATOR FIELD CIRCUIT LOW (POSSIBLE WIRE HARNESS CHAFFING), P207F REDUCTANT QUALITY PERFORMANCE (PERFORMED STATIC REGEN AND CLEARED CODES, CODES CAME BACK ON TEST DRIVE (RECOMMEND STARTING WITH REPLACING FRONT AND REAR NOX SENSORS). 10-17-22 H.G. 11:15AM AFTER REPAIR: BATTERY LIGHT IS STILL ON AND CODE COMES BACK FOR GENERATOR FIELD (RECOMMEND MORE DIAG TO CONFIRM CAUSE), BATTERIES TEST OK AND ALTERNATOR IS WORKING, TEST DROVE AND TRUCK RUNS GOOD WITH OTHER ISSUES AT THIS TIME. 10-19-22 H.G. 4PM
NITROGEN OXIDE SENSOR – REMOVE AND REPLACE (BOTH)
GARY O. gave our service a 5 star review on 10/20/2022
2005 Ford Pickup
Mileage
235,184
Service Date
9/22/2022
Services Performed
REMOVE AND REPLACE; INJECTORS (ALL), HPOP, TURBO UP PIPES (BOTH), ICP, IPR, GLOW PLUGS (ALL), GLOW PLUG HARNESS (BOTH), OIL PRESSURE SWITCH, ENGINE OIL FILTER, AND FUEL FILTER. REMOVE AND REPLACE WITH UPGRADED; NEW CYLINDER HEADS (BOTH), ARP HEAD STUDS, BULLET PROOF EGR COOLER, BILLET WATER PUMP IMPELLER, PUSH RODS (ALL), AND ROCKER CLIPS (ALL). NEED ADDITIONAL TIME FOR ANY AFTERMARKET COMPONENTS THAT MAY INTERFERE IF CAB OFF PROCEDURE IE; WIRING AIR LINES THROUGH CAB, WINCH, BUMPER, AND CAB OR BED RACK ETC.
ENGINE OIL PAN – REMOVE AND REPLACE
TURBOCHARGER – REMOVE AND REPLACE
CHECK IF EGR COOLER IS (BULLET PROOF). BLUE SPRING ALREADY DONE. CHECK POWER STEERING AND TRANSMISSION LEAK. OIL PAN. CLEAN TURBO.
JUSTIN G. gave our service a 5 star review on 9/22/2022
2005 Ford Pickup
Mileage
162,632
Service Date
8/15/2022
Services Performed
REMOVE AND REPLACE OIL PRESSURE SENSOR/SWITCH CONNECTOR
FOUND PLUG TO OIL PRESSURE SENSOR/SWITCH WITH MISSING ELECTRICAL CONNECTOR LOCK. ALSO ABOUT THREE QUARTS LOW ON ENGINE OIL. REPAIRED WIRE CONNECTOR AND TOPPED OFF ENGINE OIL.
RICHARD P. gave our service a 5 star review on 8/15/2022
2011 Ford Pickup
Mileage
158,888
Service Date
7/14/2022
Services Performed
HIGH PRESSURE FUEL CONTAMINATION SYSTEM KIT – Replace – F250 Super Duty,F350 Super Duty w/o Dual Rear Wheels – [Includes: Replace the High Pressure Pump, Fuel Rails, all Injectors and Engine Fuel Lines as instructed from the manufacturers service bulletin
CYLINDER HEAD GASKET – Remove & Replace – F250 Super Duty,F350 Super Duty,Diesel Right Side,w/o Dual Wheels – [Includes: Remove carbon and check surfaces for warpage. Includes adjust Valves (where applicable) and clean and adjust Spark Plugs.]
TRANSMISSION SERVICE-FLUID &FILTER
MACHINE TIME TO REMOVE BROKEN INJECTOR BOLTS
TOW -IN
WAYNE M. gave our service a 5 star review on 7/14/2022
2004 Ford Pickup
Mileage
127,849
Service Date
6/14/2022
Services Performed
TRANSMISSION ASSEMBLY – Remove & Replace – F250 Super Duty,F350 Super Duty,Diesel,4WD
BILLET TORQUE CONVERTER
TURBOCHARGER – Remove & Replace – F250 Super Duty,F350 Super Duty,6.0L Eng
JAMES B. gave our service a 5 star review on 6/15/2022
2004 Ford Pickup
Mileage
170,725
Service Date
3/17/2022
Services Performed
CHARGE BATTERIES DIAG RUN CODES, OIL LEAK HIGH PRESSURE OIL ONLY REACHING 250 NEED AT LEAST 400 TO START REC TEST FOR HIGH PRESSURE OIL LEAK
TDD TOW-IN TOLD CUST $75 HOOK/UP AND $5 PER MILE R/T
FIND HIGH PRESSURE OIL LEAK/LOSS
CHRIS H. gave our service a 5 star review on 3/17/2022

Ford

We Service and Repair all Ford cars