Ford Archives - Page 2 of 7 - The Diesel Doctor

2008 Ford Pickup
Mileage
213,438
Service Date
4/18/2025
Services Performed
REMOVE AND REPLACE BREAK SWITCH
TEF K. gave our service a 5 star review on 4/20/2025
2005 Ford F550 Super Duty
Mileage
179,291
Service Date
3/6/2025
Services Performed
FOUND: NO OIL ON THE DIPSTICK – JB BU, BATTERIES COMPLETELY DEAD AND WOULD NOT TAKE A CHARGE, (RECOMMEND BATTERIES AND POSSIBLY A COMPRESSION TEST) C.E. 2/25/25 INSTALLED BATTERIES CRANKED OVER, STARTED COMPRESSION TEST ON FIRST GLOW PLUG GOT SEIZED, VERY LOUD COMPRESSION LEAK COMING FROM INTAKE, ALL SIGNS ARE POINTING TO BLOWN ENGINE, C.E. M.U. 2/28/25 2PM
ROCKY O. gave our service a 5 star review on 3/7/2025
2004 Ford Pickup
Mileage
160,060
Service Date
2/21/2025
Services Performed
AXLE SHAFT SEAL – REMOVE AND REPLACE
FRONT AXLE U-JOINT – REMOVE AND REPLACE (BOTH AT WHEEL)
FRONT BRAKES – REMOVE AND REPLACE; CALIPERS, PADS, AND ROTORS
ERIC H. gave our service a 5 star review on 2/22/2025
2004 Ford Pickup
Mileage
167,226
Service Date
2/19/2025
Services Performed
FOUND: SIGNS OF POSSIBLE RECENT DRIVELINE FAILURE (RECOMMEND REBUILDING DRIVELINE), AND REAR PINION SEAL HAS SIGNS OF DAMAGE (RECOMMEND PULLING REAR DIFFERENTIAL COVER TO INSPECT FOR POSSIBLE DAMAGE, IF NO DAMAGE RECOMMEND REPLACING PINION SEAL). 2-12-25 M.E. 2PM AFTER REPAIRS: TEST DROVE AND HAVE NO SHAKING DURING ACCELERATION OR DECELERATION AT THIS TIME. L.U. 2/17/25 4PM
REAR DRIVE LINE – REMOVE SEND OUT FOR REBUILD AND REINSTALL
KRIS R. gave our service a 5 star review on 2/21/2025
2014 Ford F-250 Super Duty
Mileage
137,800
Service Date
2/19/2025
Services Performed
FOUND: INTERCOOLER FAILING, (RECOMMEND REPLACEMENT) INTERCOOLER HOSE HOT SIDE IS BLOWN, (RECOMMEND REPLACING), VACUUM PUMP IS LEAKING (RECOMMEND REPLACING), EGR GASKETS LEAKING, (RECOMMEND REPLACING) RADIATOR HOSE IS LEAKING (RECOMMEND HOSE AND THERMOSTAT) C.E. 2/13/25 1PM
INTERCOOLER – REMOVE AND REPLACE
CHARGE AIR COOLER HOSE – REMOVE AND REPLACE
THERMOSTAT &/OR GASKET – REMOVE AND REPLACE
EGR COOLER GASKETS – REMOVE AND REPLACE
VACUUM PUMP – REMOVE AND REPLACE
KEN K. gave our service a 5 star review on 2/20/2025
2014 Ford F-350 Super Duty
Mileage
164,750
Service Date
2/11/2025
Services Performed
NO BROKEN BOLTS ON EXTRACTION NO LEAKS AT THIS TIME- K.D. 2/11/25 1PM
RICK J. gave our service a 5 star review on 2/11/2025
2004 Ford Pickup
Mileage
158,834
Service Date
1/16/2025
Services Performed
SHORT BLOCK – REMOVE, OVERHAUL, AND REINSTALL (USED ASSEMBLY)
FOUND: NO EXHAUST LEAKS FOUND (RECOMMEND CONTINUE DIAGNOSTICS). 10-1-24 M.U. L.U. 3PM
FOUND: NO LEAKS AT THIS TIME. 1-6-25 M.U. 2PM
FOUND: NO DAMAGE AT THIS TIME (RECOMMEND CONTINUED DIAGNOSTICS). 1-8-25 M.E. 3PM CONTINUED: BLEW THROUGH TRANSMISSION COOLER LINES FROM INLINE FILTER THROUGH COOLER WITH NO RESTRICTIONS (RECOMMEND REPLACING INLINE FILTER AND CONTINUE DIAGNOSTICS). 1-9-25 M.E. M.U. 10AM
AFTER REPAIRS: FOUND TRANSMISSION FLUID NOT OVERHEATING AND FLOWING PROPERLY AT THIS TIME (SUSPECT BAD INLINE FILTER WAS CAUSE OF RESTRICTION (HAD UNKNOWN AFTERMARKET FILTER) AND OVERHEATING CONDITION)(ADVISE CUSTOMER TO MONITOR TRANSMISSION FOR POSSIBLE OVER HEAT DAMAGE THAT IT MAY HAVE CAUSED (SHIFTING FUNNY OR ANY OTHER CONCERNS)). 1-14-25 M.E. M.U. L.U. 5PM
FROM: THE DIESEL DR 17722 67TH AVE NE ARLINGTON WA 98223 TO: CUSTOMER HOUSE 30308 EAST SCOUTEN LOOP RD ARLINGTON WA 98223
ERIC H. gave our service a 5 star review on 1/17/2025
2008 Ford Pickup
Mileage
159,380
Service Date
1/7/2025
Services Performed
FOUND: VACUUM PUMP IS LEAKING (RECOMMEND RESEALING). 1-2-25 C.E. 2PM
VACUUM PUMP – REMOVE, RESEAL, AND REINSTALL (INCLUDES TIME FOR SERPENTINE BELT)
DAVE C. gave our service a 5 star review on 1/7/2025
2012 Ford Pickup
Mileage
102,783
Service Date
12/13/2024
Services Performed
FOUND: SCANNED NO MAJOR CODES AT THIS TIME, NOTICED HARD SHIFT BETWEEN 2ND AND 3RD, ALSO NOTICED CHATTER IN TO 3RD ON DOWN SHIFT, FRONT BRAKES ABOUT 60%, REAR BRAKES ABOUT 40%, FRONT INNER AXLE SEALS LEAKING, (RECOMMEND INNER AXLE SEALS), PLAY IN AXLE U-JOINTS, (RECOMMEND AXLE U-JOINTS), PLASTIC LOWER OIL PAN, (RECOMMEND METAL UPGRADE), CARRIER BEARING SHOT, (RECOMMEND CARRIER BEARING WITH LESS DROP BRACKET), FRONT AND REAR DIFFERENTIAL FLUID OK, TRANSFER CASE FLUID LOW AND DIRTY, (RECOMMEND SERVICE), MINOR PLAY IN BALL JOINT AT TRACK BAR, REST OF STEERING AND SUSPENSION IS GOOD, STOCK INTAKE, (RECOMMEND UPGRADING TO S&B FILTER SYSTEM), TRANSMISSION FLUID DARK, (RECOMMEND STARTING WITH TRANSMISSION SERVICE, POSSIBLY STILL MAY NEED A REBUILD IF PROBLEM PERSISTS), AFTERMARKET CCV HOSE IS KINKED, (RECOMMEND NEW HOSE), HOOD STRUTS WEAK, (RECOMMEND REPLACING), FRONT DRIVER VACUUM HOSE TO HUB BROKEN, (RECOMMEND REPLACING). M.E. 10/28/24 10AM DURING REPAIRS: WERE ABLE TO TURN FRONT ROTORS AND REAR ROTORS WERE NOT ABLE TO BE TURNED (WE REPLACED)
FRONT AXLE SHAFT SEAL – REMOVE AND REPLACE (BOTH INNER)
U-JOINT – REMOVE AND REPLACE (BOTH FRONT AT WHEEL)
FRONT BRAKES – REMOVE AND REPLACE; CALIPERS, HOSES, ROTORS (BOTH SIDES)
REAR BRAKES – REMOVE AND REPLACE; PADS, ROTORS, (BOTH SIDES)
TRANSMISSION OIL FILTER – REMOVE AND REPLACE
TRANSFER CASE FLUID – DRAIN AND FILL
CENTER SUPPORT BEARING – REMOVE AND REPLACE
FUEL FILTER – REMOVE AND REPLACE (BOTH)
ENGINE OIL PAN – REMOVE AND REPLACE (LOWER)
MAIN CONTROL VALVE BODY – REMOVE AND REPLACE
SCOTT A. gave our service a 5 star review on 12/13/2024
2014 Ford F-350 Super Duty
Mileage
163,156
Service Date
11/25/2024
Services Performed
FOUND: SCANNED CODES P0401 EGR "A" INSUFFICIENT FLOW, C0034-13 RIGHT FRONT WHEEL SPEED SENSOR, MASS AIR FLOW SENSOR READING ERRATIC, WIRING LOOKED GOOD, (RECOMMEND STARTING WITH MASS AIR FLOW SENSOR, AND FLASHING PCM TO MOST RECENT UPDATE PER TSB, THEN RETEST) POSSIBLY COULD NEED EGR VALVE AND EGR COOLER IF PROBLEM PERSISTS, C.E. 11/18/24 3PM
MASS AIR FLOW SENSOR – REMOVE AND REPLACE
RICK J. gave our service a 5 star review on 11/25/2024

Ford

We Service and Repair all Ford cars